Product ID:COUPLING GREASE
MSDS Date:10/01/1996
FSC:9150
NIIN:00N091594
Status Code:A
MSDS Number: CJMST

Emergency Phone: 800-447-8736

Info Phone: 312-856-3907

Cage: 15958

Telephone: 800 447-8735

Cage: 15958

RESIDUAL OILS (PETROLEUM), SOLVENT-REFINED; (LOW VISCOSITY

CAS: 64742-01-4

LITHIUM SOAP THICKENER

POLYETHYLENE

CAS: 9002-88-4

RTECS: KX3270000

POLYUREA THICKENER

Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: NO SIGNIFICANT HEALTH
HAZARDS IDENTIFIED. SKIN CONTACT: PROLONGED OR REPEATED CONTACT MAY
PRODUCE SOME SKIN IRRITATION. INHALATION: NO SIGNIFICANT HEALTH
HAZARDS IDENTIFIED. INGESTION: NO SIGNIFICANT HEALTH HAZARDS
IDENTIFIED. HMIS CODE: (HEALTH-0) (FLAMMABILITY:1) (REACTIVITY:0).
NFPA CODE: (HEALTH:0) (FLAMMABILITY:1) (REACTIVITY:0).
Effects of Overexposure:SEE HEALTH HAZARDS.

First Aid:EYE: FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
SKIN: WASH EXPOSED SKIN WITH SOAP AND WATER. GET MEDICAL ATTENTION
IF IRRITATION DEVELOPS. INHALATION: IF ADVERSE EFFECTS OCCUR,
REMOVE TO UNCONTAMINATED AREA. INGESTION: IF A LARGE AMOUNT IS
SWALLOWED, GET MEDICAL ATTENTION.

Flash Point Method:COC
Flash Point:=93.3C, 200.F
MINIMUM
Lower Limits:NOT DETERM
Upper Limits:NOT DETERM
Extinguishing Media:AGENTS APPROVED FOR CLASS B HAZARDS (EG, DRY
CHEMICAL, CARBON DIOXIDE, FOAM, STEAM) OR WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE IDENTIFIED. FLAMMABILITY
CLASSIFICATION: NOT FLAMMABLE. HAZARDOUS COMBUSTION PRODUCTS:
INCOMPLETE BURNING CAN PRODUCE CARBON MONOXIDE AND/OR CARBON
DIOXIDE AND OTHER HARMFUL PRODUCTS.

Spill Release Procedures:REMOVE MECHANICALLY OR CONTAIN ON AN ABSORBENT
MATERIAL SUCH AS DRY SAND OR EARTH.

Handling and Storage Precautions:NO SPECIAL REQUIREMENTS.

Respiratory Protection:USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN . NONE REQUIRED; HOWEVER, USE OF ADEQUATE
VENTILATION IS GOOD INDUSTRIAL PRACTICE.
Ventilation:CONTROL AIRBORNE CONCENTRATIONS BELOW THE EXPOSURE
GUIDELINES.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
WEAR PROTECTIVE CLOTHING AND GLOVES IF PROLONGED OR REPEATED SKIN
CONTACT IS LIKELY.
Work Hygienic Practices:USE OF EYE PROTECTION IS GOOD INDUSTRIAL
PRACTICE.
Supplemental Safety and Health
PHYSICAL DATA: DROPPING POINT: 350F(177C) (MINIMUM). PENETRATION:
320-365 DMM AT 77F. FED REG INFO: FOOD CNTCT STATUS: USDA - H2
STATUS: PROD IS ACCEPTABLE TO USDA FOR USE AS LUBRICANT IN
OFFICIAL ME AT & POULTRY ESTABLISHMENTS PROVIDED THERE IS NO POSS
OF LUBRICANT OR LUBRICATED PART CONTACTING EDIBLE PRODS.

Boiling Pt:B.P. Text:NOT DETERMINED
Melt/Freeze Pt:M.P/F.P Text:NOT DETERM
Vapor Pres:NOT DETERMINED
Vapor Density:NOT DETERM
Spec Gravity:NOT DETERMINED
pH:NOT DETERMINED
Solubility in Water:NEGLIGIBLE, BELOW 0.1%
Appearance and Odor:GREASE.

Stability Indicator/Materials to Avoid:YES
AVOID CHLORINE, FLUORINE AND OTHER STRONG OXIDIZERS.
Stability Condition to Avoid:NONE IDENTIFIED.
Hazardous Decomposition Products:NONE IDENTIFIED.

Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS.

Toxicological Information:ACUTE TOXICITY DATA: EYE IRRIT, SKIN IRRIT,
DERMAL LD50, ORAL LD50, INHAL LC50: TESTING NOT CONDUCTED. SEE
OTHER TOXICITY DATA. OTHER TOXICITY DATA: SPECIFIC TOXICITY TESTS
HAVE NOT BEEN CONDUCTED ON THIS PROD. OUR HAZ EVALUATION IS BASED
ON INFO FROM SIMILAR PRODS, INGREDS, TECHNICAL LITERATURE &/OR
PROFESSIONAL EXPERIENCE. NO COMPONENT OF THIS PROD PRESENT AT
LEVELS GREATER THAN 0.1% IS IDENTIFI ED AS A CARCINOGEN BY THE US
NATIONAL TOXICOLOGY PROGRAM, US OCCUPATIONAL SAFETY & HEALTH ACT OR
INTERNATIONAL AGENCY ON RESEARCH ON CANCER (IARC).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:ECOLOGICAL TESTING HAS NOT BEEN CONDUCTED ON THIS PRODUCT.

Transport Information:US DEPT OF TRANSPORTATION - SHIPPING NAME: NOT
REGULATED. INTERNATIONAL INFO - SEA (IMO/IMDG) SHIPPING NAME: NOT
DETERMINED. AIR (ICAO/IATA) SHIPPING NAME: NOT DETERMINED. EUROPEAN
ROAD/RALL (ADR/RID) SHIPPING NAME: NOT DETERMINED. CANADIAN
TRANSPORTATION OF DANGEROUS GOODS SHIPPING NAME: NOT REGULATED.

SARA Title III Information:SARA TITLE III SECTION 302 EXTREMELY
HAZARDOUS SUBSTANCES (40 CFR PART 355): THIS PRODUCT IS NOT
REGULATED UNDER SECTION 302 OF SARA AND 40 CFR PART 355. SARA TITLE
III SECTIONS 311/312 HAZARDOUS CATE GORIZATION (40 CFR PART 370):
THIS PRODUCT IS NOT REGULATED UNDER SARA TITLE III SECTION 311/312.
SARA TITLE III SECTION 313 (40 CFR PART 372): THIS PRODUCT IS NOT
REGULATED UNDER SECTION 313 OF SARA AND 40 CFR PART 372.
Federal Regulatory Information:CERCLA SECTIONS 102A/103 HAZ SUBSTANCES
(40 CFR PART 302.4): PROD IS NOT REPORTABLE UNDER 40 CFR PART
302.4. US INVENTORY (TSCA): LISTED IN INVENTORY. OSHA HAZARD
COMMUNICATIONS STD: CNTNS COMPONENT L ISTED BY OSHA. CNTNS
COMPONENT LISTED BY ACGIH. WHMIS CONTROLLED PROD CLASSIFICATION:
NOT CONTROLLED PROD UNDER CANADA'S WORKPLACE HMIS. EC INVENTORY
(EINECS/ELINCS): NOT DETERM. JAPAN INVENTORY (MITI ): NOT DETERM.
AUSTRALIA INVENTORY (AICS): NOT DETERM. KOREA INVENTORY (ECL): NOT
DETERM. CANADA INV ENTORY (DSL): ONE/MORE OF COMPONENTS OF PROD IS
NOT LISTED ON DSL. PHILIPPINE INVENTORY (PICCS): NOT DETERM.
(SUPDAT)
State Regulatory Information: